modern heating boiler

Details


  • Production capacity: 7-70 MW
  • Work pressure: 1.0-1.6 Mpa
  • Applicable fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, etc.
  • Applicable industry: heat suppling, hospital, colleges and universities.


Product introduction

  SZS Series Boiler is double drums, longitudinal arranged, "D" type chamber structure. Furnace is on right side and convection tube bundle is on the left. The body is fixed on the basement by middle and both end flexible supports and make the boiler to expand horizontally to sideways. Around furnace is membrane water cooling tube wall. Furnace and tube bundle is totally separated by the membrane water tube cooling wall at the left side of the furnace. The back part of bundle is sparse shift structure, front part is aligned structure. Smoke from furnace outlet enters re-burning chamber, bundle area, and then from left front part enters spiral fin coil economizer and condenser, finally discharged to atmosphere through chimney.





Safety

  Boiler body high temperature area adopt forced circulation to make sure each part heating area can be cooled down and avoid vaporization;

  Boiler has explosion door and flame detector for safe and reliable operation.

  comb plates are used as the sealing between both sides of boiler and tube bundle all use to avoid leakage of condensate and gas which is caused by refractory concrete sealing.

  air tightness test is done before leaving the factory to ensure no leakage of gas.

environmental protection

  Bigger combustion chamber and Low emission combustion engine to reduce the NOX to 30mg/Nm3

  Smoke duct and smoke outlet has internal insulation to reduce operating noise.

  Combustion chamber use full membrane water cooling wall structure, pressurized firing without smoke mixture.

energy conservation

  Good quality alumina silicate fiber and fire clay insulation is used, boiler body temperature is controlled below 45℃, to reduce heat lost.

  Combustion chamber use narrow distance tube membrane water cooling wall which has good air tightness, and reduce heat lost and increase boiler thermal efficiency.

  Inside of Inspection holes use high-alumina refractory and man hole cover sealing devices, it solved the high temperature of this part by using refractory brick

Convenience

  Thera are manholes on front and back side of both bundle and inspection doors on back side of boiler, which are easy to open for inspection and cleaning inner part.

longer lifespan

  Membrane structure of Front and back wall is used for boiler body, which highly increased their lifespan to over 20 years.

  The key part such as material cutting, rolling, drilling are proceeded by advanced CNC machining process to reduce the assemble stress and extend boiler working lifetime.

  flutter prevention fastener is used for high temperature part convection tube, which avoid bundle tube cracking problem.

  Longitudinal and girth joint adopt advanced automatic submerged-arc welding for good welding quality. All longitudinal and girth joint will have 100% radiographic inspection.

 
Items
Model
SZS7-1.0/115/70-Q SZS10.5-1.0/115/70-Q SZS14-1.25/115/70-Q SZS17.5-1.25/115/70-Q SZS21-1.25/130/70-Q SZS29-1.25/130/70-Q SZS46-1.6/130/70-Q SZS58-1.6/130/70-Q SZS70-1.6/130/70-Q SZS116-1.6/130/70-Q
Rated thermal power(MW) 7.0 10.5 14.0 17.5 21.0 29 46 58 70 116
Rated working pressure(MPa) 1.0 1.0 1.25 1.25 1.25 1.25 1.6 1.6 1.6 1.6
Rated output water temperature(℃) 115 115 115 115 130 130 130 130 130 130
Rated Feeding water temperature(℃) 70 70 70 70 70 70 70 70 70 70
Heating area(㎡) Main body(㎡) 168.0 220.0 245.30 284.40 394.75 428.1 1065.9 1225.7 1408.4 6164.8
Condenser (㎡) 164.0 306.0 527.0 645.1 738.3 990.8 985.3 1292.5 1642.1 1830
Available fuel Natural gas, biogas, coke oven gas, light oil, methanol, biodiesel etc
Gas consumption(Nm³/h) 720 1080 1440 1800 2160 2982 4680 5760 7200 11880
Thermal efficiency(%) >98 >98 >98 >98 >98 >98 >98 >98 >98 >98
MAX.transportation weight(t) 42.0 48.0 52.5 57.5 65.0 72.5 散件12.6 散件13.8 散件16 散件20
MAX. transportation dimension LxWxH(m) 7.87x3.40x3.34 8.85x3.85x3.93 8.51x3.85x3.75 9.31x3.77x3.75 10.10x4.13x4.15 10.90x4.13x4.15 11.00xΦ1.45 11.10xΦ1.46 12.00xΦ1.66 12.50xΦ1.66

CONTACT FORM



Double boil without trouble - CNET

How Fender turned Jimi Hendrixs Strat into a modern players Double boil without trouble. Double boilers can be a bit of heat-resistant and

Hive from British Gas puts heating control in your hand

Hive from British Gas puts heating It connects the thermostat and your boiler to the Hive from British Gas puts heating control in your hand (pictures)

Waste to energy: Green or greenwash? - CNET

Waste to energy: Green or greenwash? A visit to a modern waste-to-energy plant shows they are far cleaner than older incinerators and an alternative to

Nest Learning Thermostat review - CNET

The Heat Link connects to your boiler and talks to the Thermostat wirelessly Andrew Hoyle/CNET If you have a boiler and a hot water

These smart thermostats steal the heating and cooling

These smart thermostats steal the heating and cooling spotlight. If youve been thinking about swapping out your old thermostat, one of these newfangled

Why I bought two tons of wood heating pellets - CNET

Why I bought two tons of wood heating pellets. With the winter coming, CNETs Martin LaMonica gets a fresh load of home heating pellets and takes stock of

Nest Learning Thermostat review - Page 2 - CNET

If you have the right sort of boiler and don more about the gadget lust and being able to switch on your heating from Nest Learning Thermostat review:

Nest Learning Thermostat review - CNET

The Good Easy to install and easy on the eyes, the Nest Learning Thermostat learns your heating and cooling preferences over time, so you dont have to

Appliance Science: The high-pressure physics of espresso

Appliance Science: The high-pressure physics is the heat exchanger machine with a single boiler. high-pressure physics of espresso coffee.

These smart thermostats steal the heating and cooling

These smart thermostats steal the heating and cooling but some clever tweaks gave it modern and that which will cause the least stress to your boiler is :-

Nest Learning Thermostat review - Page 2 - CNET

If you have the right sort of boiler and don more about the gadget lust and being able to switch on your heating from Nest Learning Thermostat review:

These smart thermostats steal the heating and cooling

The Nest thermostat is less efficient than the old fashioned stress to your boiler and a 24 kilowatt auxiliary heat strip. The thermostat

Waste to energy: Green or greenwash? - CNET

Waste to energy: Green or greenwash? A visit to a modern waste-to-energy plant shows they are far cleaner than older incinerators and an alternative to

Rice cookers a revelation? - Chowhound

The double boiler is a simple way to Normal modern absorption rice cookers all have heat contact with Read the Rice cookers a revelation? discussion from

This Old House - Season 19 - TV.com

In the basement, Richard discusses the new heating plant (a combination boiler and hot water tank) who explains the workings of a modern Rumford fireplace,

Appliance Science: The high-pressure physics of espresso

Appliance Science: The high-pressure physics is the heat exchanger machine with a single boiler. high-pressure physics of espresso coffee.

How to install the Nest Learning Thermostat - CNET

How to install the Nest Learning Thermostat. the way we approach heating and cooling with technology and design fit for the gadget lover in a modern

Old Mexico + Modern Flavors = Mod Mex - CBS News

Old Mexico + Modern Flavors = Mod Mex Comment; Add the butter and the onion and sauté over medium heat until the onion turns lightly brown, or boiler. Wrap

EPA to delay CO2 permit requirements for biomass - CNET

To encourage the use of clean energy, agency says it will defer permitting requirements for CO2 emissions from biomass-fired and other biogenic sources for three years.

This Old House: The San Francisco House - 5 - TV.com

Watch This Old House - Season 19, Episode 24 - The San Francisco House - 5: The crew visits Coloma, California, where the Gold Rush began in 1848, to see Sutters